Ultra Air Hockey for PC released! (V1.0)
Ultra Air Hockey for PC was released over spring break during March 2014! You can download it from here. It will be ported to the Sega Genesis/Sega CD over summer 2014. Enjoy, and have fun!
The blog of EagleSoft Ltd! At EagleSoft Labs, I post about the development of my various retro homebrew and video game mods, Indie video game projects, software, and electronics. I also review software, and post about other geeky/nerdy stuff.
An XF551 unit
|
6. Slowly and carefully, lift the FDD Mech off the chassis, and onto the side outside of the chassis frame. Be careful, beacause the FDD Mech is still attached to the ribbon cable-like thing!
7. Remove the three screws from the controller PCB, and place them on the paper in the circle marked "PCB Frame". (See photos)
(There is a screw inside that hole on the metal frame)
8. Carefully, pull the board away from the back side of the bottom of the chassis, and pull the board up. You need to get the SIO connectors out of the chassis cutout, and the PCB board above the white plastic holders. This takes some time...
(White plastic holders are at tip of pens)
9. In the bottom left corner of the PCB board, notice the firmware chip and PCB revision text. Note whether the firmware chip is socketed or not (mine is). Also write down on the piece of paper the text on the chip and the Board/Revision number of the PCB. You will need this information later for reference, if you actually decide to do the XF351 upgrade.
10. Inspect the solder joints on both the PCB and on the FDD Mech. Especially check the wire solder joints on the FDD Mech, and the solder joints on on the connectors on the back of the FDD, especially the power jack. Remember, unless you got your FDDs NIB, these FDDs are more than 20 years old, so things shall have worn out! If you are skilled enough (and I am assuming that you are, since you are reading this electronics-based retro guide), add new solder to joints that need them. Also, optionally, lightly and carefully, apply WD-40 to rusty spots on the chassis of the FDD Mech.
(Gosh, looks like that black wire broke off of its solder joint, on the bottom of the FDD Mech! I need to eventually resolder it, if it is not some kind of ground wire. This particular FDD unit kept giving me boot errors, even before I opened it up. This broken wire is probably the cause...)
(The metal on the power jack looks rusty. I need to apply eventually some WD-40)
(Looks like the solder joints on the bottom of the switch and power jack need new solder too...)
(Oxidation! Apply WD-40 lightly!)
11. Take the plastic chassis halves to a sink. Run lukewarm water from the sink's faucet, and quickly but thoroughly clean off the dust, rust, and other mess from the two chassis halves. Also, lightly wet the "air vents" on the top of the chassis. Afterwards, wipe the majority of the reamining water with a towel. Finally, wipe the rest of the water using a cotton swab, and some of it quickly using a hair dryer on warm. Let everything air drive after you are done. Remember, the plastics are more than 20 years old, so do not apply too much heat; it could crack!
12. Do whatever else you want to do (ie, the XF351 upgrade), and then reassemble everything, in reverse order!
=========== I hope you liked the guide and find it useful. Soon, I will be trying to do that XF351 conversion after purchasing the upgraded firmware chip, as well as diassembling/cleaning out the 2nd FDD. I will post a video walkthrough on when removing the 2nd unit. |